Swashplate Actuator and Flaperon / Elevator Actuator Test Stands

Agency: Department of the Navy
State: New Jersey
Type of Government: Federal
Caegory:
  • 49 - Maintenance and Repair Shop Equipment
Posted Date: Oct 10, 2017
Due Date:
Solicitation No: N68335-15-R-0628_
Bid Source: Please Login to View Page
Contact information: Please Login to View Page
Bid Documents: Please Login to View Page
Solicitation Number :
N68335-15-R-0628_
Notice Type :
Award
Contract Award Date :
September 22, 2017
Contract Award Number :
N6833517C0683
Contract Award Dollar Amount :
$8,725,000
Contractor Awarded Name :
Moog Inc.
Contractor Awarded DUNS :
002103166
Contractor Awarded Address :
400 Jamison Rd Plant 26
Elma, New York 14059
United States
Synopsis :
Added: Jul 09, 2015 4:46 pm
The Naval Air Warfare Center Aircraft Division Lakehurst NJ intends to enter into negotiations on a non-competitive basis with Moog, Inc., Aurora, New York, for a quantity of one each, Swashplate Actuator Test Stand (TS) (P/N E95002-002) and Falperon/Elevator Actuator TS (P/N E95002-003) to be produced and installed at the Fleet Reserve Center-East (FRC-E), Cherry Point, North Carolina. Moog is the original equipment manufacturer of these TSs. The Swashplate Actuator and the Flaperon/Elevator Actuator TSs have been identified to fulfill a requirement to complete acceptance tests on the Swashplate (C30840-001), Flaperon (C29215-001), and Elevator (C29855-001) servo actuator assemblies of the V-22 Aircraft as part of depot repair and overhaul.
The Government-owned system currently in use for V-22 Swashplate, Flaperon, and Elevator actuator testing is located at Moog. The TS includes mechanical test fixtures, with hydraulic pump systems and electronic test consoles. The TS / test fixtures located at Moog's facility are the only TSs / fixtures to certify these actuators as Ready For Issue (RFI). To assure standardized application of acceptance test procedures and consistent test results across both Moog and FRC-E sites, the additional TSs must be fully compatible in form, fit and function with the existing Government owned TSs currently installed at Moog. Delivery will be fob destination, 24 months after the date of the contract.

The Government does not possess adequate data and/or rights necessary to competitively award this contract. Because Moog Aircraft Group designed, developed, qualified, and still maintains configuration control of the V-22 Swashplate, Flaperon and Elevator Actuators and the test stand required for the specified component testing, Moog is uniquely qualified to provide the TSs required. Moog is the only known company that possesses all the technical data, drawings, specifications, and Logistics Supportability Analysis data necessary to fulfill the Government's requirements. Although high-level drawings for the TS were provided to the Government, the Government has only limited data rights for these and cannot provide access to the necessary information to other potential manufacturers. In addition, since the data was received, there have been numerous changes to the stands, driven by proprietary modifications, to which the Government does not have any data rights or has only limited rights.
The Government intends to procure this requirement under the authority of 10 USC 2304 (c) (1) as implemented by the Federal Acquisition Regulations (FAR) Section 6.302-1. All responsible sources may submit a response which may be considered by the Government in determining whether to conduct a competitive procurement. THIS IS NOT A REQUEST FOR PROPOSALS. A determination by the Government not to open the requirement to competition based on the responses to this notice is solely within the discretion of the Government. Information provided herein is subject to change and in no way binds the Government to solicit for an award of a contract.

Please consult the list of document viewers if you cannot open a file.
J&A
Type:
Other (Draft RFPs/RFIs, Responses to Questions, etc..)
Label:
J&A
Posted Date:
October 10, 2017
Description: J&A_15_24803
Contracting Office Address :
Contracts Department
Hwy. 547 Attn:B562-3C
Lakehurst, New Jersey 08733-5083
Place of Performance :

Primary Point of Contact. :
Alice L Tornquist,
Conract Specialist
Phone: 732-323-4316
Fax: 732-323-7440
Secondary Point of Contact :
Maria Wells,
Contracting Offficer
Phone: 732-323-4667
Fax: 732-323-7440

Related Document

Jul 9, 2015[Presolicitation] Swashplate Actuator and Flaperon / Elevator Actuator Test Stands

Sign-up for a Free Trial, Government Bid Alerts

With Free Trial, you can:

You will have a full access to bids, website, and receive daily bid report via email and web.

Try One Week FREE Now

See Also

Opportunity History Original Synopsis Aug 06, 2018 3:56 pm Solicitation Number : N68335-18-R-0210

Department of the Navy

Bid Due: 8/21/2018

Opportunity History Complete View Original Synopsis Sources Sought Apr 26, 2018 6:31 am

Department of the Navy

Bid Due: 8/27/2018

Opportunity History Complete View Original Synopsis Presolicitation Aug 06, 2018 3:56 pm Changed

Department of the Navy

Bid Due: 8/21/2018

Opportunity History Complete View Original Synopsis Sources Sought Aug 08, 2018 6:55 pm

Department of the Navy

Bid Due: 8/24/2018