Added: Sep 03, 2008 3:36 pm
THE COANG IS REQUESTING QUOTES ON THE FOLLOWING ITEM:
2-HYDROBLASTER: MODEL 5/3000GHOTT-AWS
SPECS:
Hydroblaster
Model 5/3000GHOTT-AWS
Certified to UL 1776
GENERAL SPECIFICATIONS AND USE
This is a fully self-contained portable cleaning system. Designed for aircraft wash and flight line or ground support decontamination and cleaning. System has a capacity of 525 gallons of water, 60 gallons of soap, with a high-pressure delivery system and an auxiliary soap delivery system. The Model 5/3000GHOTT-AWS is painted desert tan.
ENGINE:
Kabota water cooled diesel engine with 8 gallon non corrosive fuel tank.
Solid base plate mounted on 3/8 plate steel.
12 volt electric starting system with key switch.
Spiral cell battery
20 amp. high energy charging system capable of providing power to the engine, battery and
burner system.
Water cooled diesel engine (Meets California emissions standards).
PUMP:
5 GPM rating.
Dual gun operation with operator controlled variable pressure wands.
4 main bearing, oil bath, hardened steel crank shaft.
Industrial triplex ceramic plunger pump.
Oil level eye and dipstick for maintenance
Belt drive.
Pressure safety relief valve.
BURNER:
Horizontal draft full stainless steel housing
12 volt burner system (no separate generator used to power the burner)
440,000 BTU; rating set to not exceed 150 degrees F.
On-demand auto ignition electronic pilot and flame monitor.
Forced air system with fuel solenoid control valve and spin on fuel filter.
Temperature high limit switch.
Burner controls assure constant temperatures.
Built-in non corrosive 12 gallon fuel oil tank.
Schedule 80 steel coil.
CONTROLS:
Complete control panel which includes engine start/stop, adjustable temperature control, hour meter.
A fully hinged stainless steel enclosure features; full access for service while providing a total equipment lock up.
Cross flow air ducting into and out of locking enclosure cools the components to manufactures specifications. SAFETY:
Fully integrated design, not a unit with a tank bolted to a trailer.
Electric trailer brakes standard on front and rear axle.
Manual park brake, lever controlled.
Flow and/or pressure switches.
Hi-temperature by-pass valve.
Flow or pressure actuated unloader valve.
2 each trigger shut-off guns with variable pressure wands
Over pressure relief valve.
Safety burst disk.
Authorized by AGSE for use on U.S. Army aircraft
INTEGRATED TRAILER:
Constructed of 3, 4 and 6 inch steel C channel.
DUAL 3500 LB. AXLES FOR 7000 GVW.
Extended leaf springs for soft ride.
Lunette eye hitch.
Full size spare tire and wheel mounted on welded channel steel bracket.
525 gallon UV protected poly water tank integrated and mounted on 6 channel iron frame.
Dump valve and fittings, all plumbed to control panel.
2 each 30 gallon soap tanks mounted on 6 channel integrated into trailer.
4 each hose reels. Two for high pressure hose, one for inlet hose, and one for auxiliary soap application system, all integrated into trailer. SPRAY SYSTEM:
2 each 100 3/8 inch high-pressure hoses mounted on hose reels.
100 5/8 rubber inlet water hose mounted on hose reel.
100 5/8 soap application hose mounted on hose reel.
Variable pressure control at the wand with 40 degree nozzles.
STORAGE AND SPARES:
Large storage / tool box
Complete aircraft wash kit
5 gallons mil spec cleaning compound
Nozzle spares kit
Spare wand set
Spare filters set
Spare hose(s) set
SEND ALL QUOTES AND QUESTIONS TO: sandra.miranda@us.army.mil
